喷射器内含湿含硫天然气形成水合物预测

doi:10.3976/j.issn.1002-4026.2022.05.009

山东科学 ›› 2022, Vol. 35 ›› Issue (5): 69-79.doi: 10.3976/j.issn.1002-4026.2022.05.009

喷射器内含湿含硫天然气形成水合物预测

徐涛¹(), 刘伟¹, 王照亮²^,^*()

1.中石化胜利油田分公司,山东东营 257000
2.中国石油大学(华东),山东青岛 266580

收稿日期:2021-09-16 出版日期:2022-10-20 发布日期:2022-10-10
通信作者: 王照亮 E-mail:S18060016@upc.edu.cn;wzhaoliang@upc.edu.cn
作者简介:徐涛(1977—),男,高级工程师,研究方向为采油工程。E-mail: S18060016@upc.edu.cn
基金资助:
中石化科技攻关项目(P20070-8)

Prediction of hydrate formation of natural gas containing moisture and sulfur in ejector

XU Tao¹(), LIU Wei¹, WANG Zhao-liang²^,^*()

1. Sinopec Shengli Oilfield Branch, Dongying 257000, China
2. China University of Petroleum, Qingdao 266580, China

Received:2021-09-16 Online:2022-10-20 Published:2022-10-10
Contact: WANG Zhao-liang E-mail:S18060016@upc.edu.cn;wzhaoliang@upc.edu.cn

摘要/Abstract

摘要：

针对高含硫气田天然气含湿含硫且井口压力不断降低的特点,利用高压气井的富余压力通过喷射器增压输送低压天然气。采用Fluent软件对喷射器内单相和气液两相含湿含硫天然气的沿程温度、压力进行了数值模拟,应用天然气水合物生成预测模型ZahediⅠ对天然气喷射器内部天然气水合物生成区域进行了预测分析,预测了工作流体入口温度、含硫量、含湿量对天然气水合物生成的影响。工作流体入口温度增加,喷射器内天然气水合物生成区域范围减小,硫化氢含量越高,天然气水合物生成区域范围越大,工作流体含水滴,喷射器内天然气水合物生成区域小于单相工质下的天然气水合物生成区域,进而提出了消除含湿含硫天然气喷射器内形成水合物的措施。

关键词: 含湿含硫天然气, 喷射器, 天然气水合物, 生成区域

Abstract:

For the continuous decrease in the wellhead pressure of natural gas containing moisture and sulfur in gas fields with high quantities of sulfur, low-pressure gases are transported owing to the surplus pressure from high-pressure gas wells via ejectors. Herein, the Fluent software is used to numerically simulate temperature and pressure profiles for single- and two-phase flows of natural gas containing moisture and sulfur in an ejector. The ZahediⅠmodel is used to predict the formation area of natural gas hydrates in the ejector. The effect of the inlet temperature of the working fluid, sulfur content, and moisture content on the formation of natural gas hydrates is predicted and analyzed. With increasing inlet temperature of the working fluid, the generation area range of natural gas hydrates in the ejector decreases. When the sulfide content is high, the generation area range of natural gas hydrates is large. The working fluid contains water droplets. The generation area of natural gas hydrates in the ejector is smaller than that under a single-phase working medium. Based on these results, measures for reducing natural gas hydrates are proposed.

Key words: natural gas containing moisture and sulfur, ejector, natural gas hydrate, formation region

中图分类号:

TK124

徐涛, 刘伟, 王照亮. 喷射器内含湿含硫天然气形成水合物预测[J]. 山东科学, 2022, 35(5): 69-79.

XU Tao, LIU Wei, WANG Zhao-liang. Prediction of hydrate formation of natural gas containing moisture and sulfur in ejector[J]. Shandong Science, 2022, 35(5): 69-79.

图/表 15

图1

图2

图3

图4

图5

图6

图7

图8

图9

图10

图11

图12

图13

图14

图15

参考文献 15

[1]	YANG Y, KARVOUNIS N, WALTHER J H, et al. Effect of area ratio of the primary nozzle on steam ejector performance considering nonequilibrium condensations[J]. Energy, 2021, 237:121483. DOI: 10.1016/j.energy.2021.121483. doi: 10.1016/j.energy.2021.121483
[2]	WANG M, CHENG Y, YU J L. Analysis of a dual-temperature air source heat pump cycle with an ejector[J]. Applied Thermal Engineering, 2021, 193: 116994. DOI: 10.1016/j.applthermaleng.2021.116994. doi: 10.1016/j.applthermaleng.2021.116994
[3]	廖刚. 放喷测试中天然气水合物形成及预防措施[J]. 钻采工艺, 2018, 41(3): 61-63. DOI: 10.3969/J.ISSN.1006-768X.2018.03.18.
[4]	庞群利. 深水油气田开发过程中的天然气水合物预测模型研究[D]. 青岛: 中国石油大学, 2010.
[5]	邵聪, 诸林, 何阳东, 等. 公式法预测天然气水合物形成条件及其评价[J]. 石油与天然气化工, 2018, 47(4): 50-56. DOI: 10.3969/j.issn.1007-3426.2018.04.010. doi: 10.3969/j.issn.1007-3426.2018.04.010
[6]	CHEN G J, GUO T M. Thermodynamic modeling of hydrate formation based on new concepts[J]. Fluid Phase Equilibria, 1996, 122(1/2): 43-65. DOI:10.1016/0378- 3812(96)03032-4. doi: 10.1016/0378-3812(96)03032-4
[7]	CHEN G J, GUO T M. A new approach to gas hydrate modelling[J]. Chemical Engineering Journal, 1998, 71(2): 145-151. DOI: 10.1016/s1385-8947(98)00126-0. doi: 10.1016/s1385-8947(98)00126-0
[8]	LI Y F, DENG J Q. Numerical investigation on the performance of transcritical CO₂ two-phase ejector with a novel non-equilibrium CFD model[J]. Energy, 2022, 238: 121995. DOI: 10.1016/j.energy.2021.121995. doi: 10.1016/j.energy.2021.121995
[9]	LI H, WANG X D, NING J X, et al. Numerical investigation of the nozzle expansion state and its effect on the performance of the steam ejector based on ideal gas model[J]. Applied Thermal Engineering, 2021, 199: 117509. DOI: 10.1016/j.applthermaleng.2021.117509. doi: 10.1016/j.applthermaleng.2021.117509
[10]	AL-ANSARY H A M, JETER S M. Numerical and experimental analysis of single-phase and two-phase flow in ejectors[J]. HVAC&R Research, 2004, 10(4): 521-538. DOI: 10.1080/10789669.2004.10391118. doi: 10.1080/10789669.2004.10391118
[11]	JONES W P, LAUNDER B E. The prediction of laminarization with a two-equation model of turbulence[J]. International Journal of Heat and Mass Transfer, 1972, 15(2): 301-314. DOI:10.1016/0017- 9310(72)90076-2.
[12]	PIANTHONG K, SEEHANAM W, BEHNIA M, et al. Investigation and improvement of ejector refrigeration system using computational fluid dynamics technique[J]. Energy Conversion and Management, 2007, 48(9): 2556-2564. DOI: 10.1016/j.enconman.2007.03.021. doi: 10.1016/j.enconman.2007.03.021
[13]	SUN C Y, CHEN G J, LIN W, et al. Hydrate formation conditions of sour natural gases[J]. Journal of Chemical & Engineering Data, 2003, 48(3): 600-602. DOI: 10.1021/je020155h. doi: 10.1021/je020155h
[14]	刘娜. 太阳能喷射式制冷系统中蒸汽喷射器性能的数值模拟[D]. 青岛: 青岛大学, 2014.
[15]	宋光春, 李玉星, 王武昌, 等. 油气混输管道中天然气水合物的形成和堵塞过程研究[J]. 石油与天然气化工, 2017, 46(2): 38-43. DOI: 10.3969/j.issn.1007-3426.2017.02.008. doi: 10.3969/j.issn.1007-3426.2017.02.008

喷射器内含湿含硫天然气形成水合物预测

Prediction of hydrate formation of natural gas containing moisture and sulfur in ejector

RichHTML

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

图/表 15

参考文献 15

相关文章 2

Metrics

本文评价

推荐阅读 0

[1]	胡文欣，张克舫，王照亮，莫琼，刘德绪. 高含硫天然气引射增压的数值模拟及硫析出分析[J]. 山东科学, 2018, 31(6): 41-49.
[2]	郭永献，张大兴，梁世强. NH₃-H₂O喷射-吸收复合式燃气热水炉系统研究及分析[J]. 山东科学, 2016, 29(2): 41-58.