单圆柱微通道内流动特性实验研究

doi:10.3976/j.issn.1002-4026.2020.04.008

山东科学 ›› 2020, Vol. 33 ›› Issue (4): 53-62.doi: 10.3976/j.issn.1002-4026.2020.04.008

单圆柱微通道内流动特性实验研究

李济超^1,2，季璨²，刘志刚^2*，李慧君¹，马超^1,2，匙文涛^1,2

1. 华北电力大学能源动力与机械工程学院，河北保定 071003； 2. 齐鲁工业大学(山东省科学院) 山东省科学院能源研究所，山东济南 250014

收稿日期:2019-12-19 出版日期:2020-07-27 发布日期:2020-07-28
通信作者: 刘志刚，男，研究员，研究方向为微通道内流动换热。E-mail: zgliu9322@163.com
作者简介:李济超（1994—），男，硕士，研究方向为微通道内流动换热。E-mail: li_jichao@foxmail.com
基金资助:
山东省科学院青年基金（2019QN0021）；山东省自然科学基金(ZR2018LE016)；山东省重点研发计划（2019GSF109074）；山东省科学院创新工程专项；山东省科学院科技发展基金（科基合字（2019）第2号）

Experimental study on flow characteristics in a microchannel with a single cylinder

LI Ji-Chao^1,2， JI Can²， LIU Zhi-gang^2*，LI Hui-jun¹，MA Chao^1,2，CHI Wen-tao^1,2

1. School of Energy, Power and Mechanical Engineering, North China Electric Power University, Baoding 071003, China; 2. Energy Research Institute，Qilu University of Technology（Shandong Academy of Sciences），Jinan 250014, China

Received:2019-12-19 Online:2020-07-27 Published:2020-07-28

摘要/Abstract

摘要： 采用Micro-PIV实验系统和压差测试系统，研究了含有单个微圆柱的通道内去离子水在10<Re<430范围内的流动特性，得到了通道不同高度流层的流线、无因次速度场、湍流强度分布以及压降。结果表明，微圆柱绕流的第一、第二临界Re分别在10和430左右；尾流区漩涡内流体存在垂直流动方向的速度，漩涡三维特征明显；当Re较低时，压降及漩涡长度随Re增加较为缓慢，黏性阻力所占的比重较大，随着Re的增加漩涡发展，形状阻力占据的比重增加，压降随Re增加幅度上升，当Re达到400左右压降随Re变化曲线斜率增大，此时尾流区流动向着漩涡脱落过渡。

关键词: 微圆柱绕流, Micro-PIV, 临界雷诺数, 漩涡, 湍流强度

Abstract: In this paper, a micro-PIV system and differential pressure measurement system is used to study the flow characteristics of deionized water in a channel with a single microcylinder in the range of 10 < Re < 430. The streamlines, dimensionless velocity field, turbulence intensity distribution of different flow layers, and pressure drop are obtained. Results show that the first and second critical Reynolds numbers of the flow around the microcylinder are approximately 10 and 430, respectively. The fluid in the wake vortex has a velocity component that is perpendicular to the flow direction, and the three-dimensional characteristics of the vortex are obvious. When Re is low, the pressure drop and the length of vortices increase slowly with Re and the viscous resistance accounts for a larger proportion. With increase in Re, the vortex gradually develops simultaneously with the increase in the proportion of shape resistance, and the pressure drop increases faster with Re. When Re = 400, the slope of the pressure drop curve rises and then gradually transforms into vortex shedding.

Key words: flow around a microcylinder, micro-PIV, critical Reynolds number, vortex, turbulence intensity

中图分类号:

TK124

李济超, 季璨, 刘志刚, 李慧君, 马超, 匙文涛. 单圆柱微通道内流动特性实验研究[J]. 山东科学, 2020, 33(4): 53-62.

LI Ji-Chao, JI Can, LIU Zhi-gang, LI Hui-jun, MA Chao, CHI Wen-tao. Experimental study on flow characteristics in a microchannel with a single cylinder[J]. Shandong Science, 2020, 33(4): 53-62.

参考文献 26

1	过增元. 当前国际传热界的热点：微电子器件的冷却[J]. 中国科学基金, 1988, 2(2): 20-25. doi: 10.16262/j.cnki.1000-8217.1988.02.007
2	过增元. 国际传热研究前沿：微细尺度传热[J]. 力学进展, 2000, 30(1): 1-6. doi: 10.3321/j.issn:1000-0992.2000.01.001
3	TULLIUS J F, TULLIUS T K, BAYAZITOGLU Y. Optimization of short micro pin fins inminichannels[J]. International Journal of Heat and Mass Transfer, 2012, 55(15/16): 3921-3932. doi: 10.1016/j.ijheatmasstransfer.2012.03.022
4	LIU Z G, WANG Z L, ZHANG C W, et al. Flow resistance and heat transfer characteristics in micro-cylinders-group[J]. Heat and Mass Transfer, 2013, 49(5): 733-744. doi: :10.1007/s00231-013-1115-1
5	SHAFEIE H, ABOUALI O, JAFARPUR K, et al. Numerical study of heat transfer performance of single-phase heat sinks with micro pin-fin structures[J]. Applied Thermal Engineering, 2013, 58(1/2): 68-76. doi: 10.1016/j.applthermaleng.2013.04.008
6	KHAN M G, FARTAJ A. A review on microchannel heat exchangers and potential applications[J]. International Journal of Energy Research, 2011, 35(7): 553-582. doi: 10.1002/er.1720
7	WANG Y Y, SHIN J H, WOODCOCK C, et al. Experimental and numerical study about local heat transfer in a microchannel with a pin fin[J]. International Journal of Heat and Mass Transfer, 2018, 121: 534-546. doi: 10.1016/j.ijheatmasstransfer.2018.01.034
8	ZDRAVKOVICH M M. Different modes of vortex shedding: an overview[J]. Journal of Fluids and Structures, 1996, 10(5): 427-437. doi: 10.1006/jfls.1996.0029
9	ROSHKO A. On the development of turbulent wakes from vortex sheets[EB/OL].[2019-10-12]. https://digital.library.unt.edu/ark:/67531/metadc56619/.
10	FORNBERG B. A numerical study of steady viscous flow past a circular cylinder[J]. Journal of Fluid Mechanics, 1980, 98(4): 819-855. doi: 10.1017/s0022112080000419
11	WILLIAMSON C H K.Oblique and parallel modes of Vortex shedding in the wake of a circular cylinder at low Reynolds numbers[J]. Journal of Fluid Mechanics, 1989, 206: 579-627. doi: 10.1017/s0022112089002429
12	YANG X, ZEBIB A. Absolute and convective instability of a cylinder wake[J]. Physics of Fluids A: Fluid Dynamics, 1989, 1(4): 689-696. doi: 10.1063/1.857362
13	PANTON R L, ANDREOPOULOS Y. Incompressible flow[J]. Physics Today, 1996, 49(11): 89-90. doi: 10.1063/1.881530
14	GREEN R B, GERRARD J H. Vorticity measurements in the near wake of a circular cylinder at low Reynolds numbers[J]. Journal of Fluid Mechanics, 1993, 246: 675-691. doi: 10.1017/s002211209300031x
15	邹帅, 徐加辉, 周杰, 等. 过渡流下钝体绕流特性的可视化实验对比[J]. 化工学报, 2016, 67(增刊1): 210-216. doi: 10.11949/j.issn.0438-1157.20160611
16	JUNG J, KUO C J, PELES Y, et al. The flow field around a micropillar confined in a microchannel[J]. International Journal of Heat and Fluid Flow, 2012, 36: 118-132. doi: 10.1016/j.ijheatfluidflow.2012.04.009
17	WANG Y Y, HOUSHMAND F, ELCOCK D, et al. Convective heat transfer and mixing enhancement in a microchannel with a pillar[J]. International Journal of Heat and Mass Transfer, 2013, 62: 553-561. doi: 10.1016/j.ijheatmasstransfer.2013.03.034
18	WANG Y Y, PELES Y. An experimental study of passive and active heat transfer enhancement in microchannels[J]. Journal of Heat Transfer, 2014, 136(3): 031901. doi: 10.1115/1.4025558
19	WANG Y Y, NAYEBZADEH A, YU X F, et al. Local heat transfer in a microchannel with a pin fin—experimental issues and methods to mitigate[J]. International Journal of Heat and Mass Transfer, 2017, 106: 1191-1204. doi: 10.1016/j.ijheatmasstransfer.2016.10.100
20	WANG Y Y, SHIN J H, WOODCOCK C, et al. Experimental and numerical study about local heat transfer in a microchannel with a pin fin[J]. International Journal of Heat and Mass Transfer, 2018, 121: 534-546. doi: 10.1016/j.ijheatmasstransfer.2018.01.034
21	XIA G D, CHEN Z, CHENG L X, et al. Micro-PIV visualization and numerical simulation of flow and heat transfer in three micro pin-fin heat sinks[J]. International Journal of Thermal Sciences, 2017, 119: 9-23. doi: 10.1016/j.ijthermalsci.2017.05.015
22	XU F Y, PAN Z H, WU H Y. Experimental investigation on the flow transition in different pin-fin arranged microchannels[J]. Microfluidics andNanofluidics, 2018, 22: 11. doi: 10.1007/s10404-017-2030-4
23	王利静. 具有自由液面流场中圆柱绕流的数值模拟研究[D]. 哈尔滨: 哈尔滨工程大学, 2008.
24	王亚玲, 刘应中, 缪国平. 圆柱绕流的三维数值模拟[J]. 上海交通大学学报, 2001, 35(10): 1464-1469. doi: 10.3321/j.issn:1006-2467.2001.10.008
25	赵萌, 毛军, 郗艳红. 高雷诺数下有限长圆柱绕流阻力特性研究[J]. 机械工程学报, 2015, 51(22): 176-182.
26	蒋赟. 阻流比与长径比对低雷诺数圆柱绕流尾迹演化的影响研究[D]. 长沙: 中南大学, 2014.

[1]	刘志刚, 吕明明, 孔令健, 贾磊, 江亚柯. 基于Micro-PIV的不同截面形状微柱群内部流场特性研究[J]. 山东科学, 2019, 32(5): 81-87.
[2]	李永，吕明明，刘志刚，祝叶. 流体绕流微柱群的Micro-PIV实验研究[J]. 山东科学, 2018, 31(6): 50-54.
[3]	管宁，刘志刚*，张承武，姜桂林，丁宁. 壁面加热对微圆柱漩涡脱落的影响[J]. 山东科学, 2015, 28(2): 31-38.

单圆柱微通道内流动特性实验研究

Experimental study on flow characteristics in a microchannel with a single cylinder

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

参考文献 26

相关文章 3

Metrics

本文评价

推荐阅读 0